granite fine sand replacement

granite fine sand replacement

granite fine sand replacement,An Innovative Method of Replacing River Sand by . - IJSERThe best way to deal with these environmental concerns is to use waste or recycled material, as substitute for natural river sand. This paper deals with replacement of sand used in concrete as fine aggregates by the waste generated by the stone quarry industry. This study has made an attempt to partially replace quarry dust.granite powder concrete - ESTIJas replacement sand with granite powder has beneficial effect on the mechanical properties such as compressive strength and split tensile strength of concrete. Keywords-Granite Powder, Compressive strength, Split tensile strength, Optimal replacement percentage. I. Introduction. Fine aggregate is an essential component.

Experimental Study on Partial Replacement of Fine . - IJIRSTThe result shows that the property of granite fines is similar to that of ordinary sand. Therefore, granite fines can be effectively used as a replacement material for fine aggregate in concrete. For investigation purpose cubes are casted with 7 different proportions of granite fines and fine aggregate. The replacement percentage.Use of Crushed Granite Fine as Replacement to River Sand in .Dec 24, 2010 . The suitability of Crushed granite fine (CGF) to replace river sand in concrete production for use in rigid pavement was investigated. Slump, compressive and indirect tensile strength tests were performed on fresh and hardened concrete.28 days Peak compressive and indirect tensile strength values of.

22 Comments

cost effectiveness of replacing sand with stonedust . - IOSR Journals

Cost Effectiveness of Replacing Sand with Crushed Granite Fine. (CGF) In the Mixed Design of Concrete. Engr. Muritala Ashola ADIGUN, B.Eng; M.Sc. Civil Engineering Department, Lagos State Polytechnic, Ikorodu, Lagos State, Nigeria. Abstract: The economic gain of replacing sand with Crushed Granite Fines in the.

An Experimental Study on Partial Replacement of Sand with . - IJSTE

crushed stone dust as fine dust and found that flexural strength increases than the concrete with natural sand but the values decreases as the percentage of crusher dust increases The choice of quarry dust as replacement for sand has been supported in the previous study (Manassa, 2010) showing that up to 20% of sand.

Experimental Study on Partial Replacement of Fine . - IJIRST

The result shows that the property of granite fines is similar to that of ordinary sand. Therefore, granite fines can be effectively used as a replacement material for fine aggregate in concrete. For investigation purpose cubes are casted with 7 different proportions of granite fines and fine aggregate. The replacement percentage.

Improved Concrete Properties Using Quarry Dust as Replacement .

One such material is Quarry stone dust: a by-product obtained during quarrying process. Attempts have been made to study the suitability of Quarry dust as sand replacing material and it has been found that Quarry . been the most popular choice for the fine aggregate component of concrete in the past, but overuse of the.

Granite powder concrete - Indian Journal of Science and Technology

compared with natural fine aggregate concrete. The test results obtained indicate that granite powder of marginal quantity as partial sand replacement has beneficial effect on the mechanical properties such as compressive strength, split tensile strength, modulus of elasticity. Furthermore, the test results indicated that the.

partial replacement of natural river sand with crushed rock . - Jkuat

Jul 27, 2013 . increasing compressive strength by use of rock flour as fine aggregate instead of river sand. The idea of using quarry sand as an alternative aggregate was developed because granite which is the parent material is hard and dense and therefore can serve as an excellent aggregate material. Its use as a fine.

granite fine sand replacement,Granite powder, Strength, Durability properties, Chloride attack .

Abstract The most commonly used fine aggregate across world is river sand. . concrete with replacement of sand by granite powder by 0, 25 and 50% and cement was partial replacement with silica fume, . Keywords Granite powder, Strength, Durability properties, Chloride attack, Tensile and compressive strength, Fine.

an experimental study on partial replacement of granite . - ijraet

Jun 1, 2017 . Concrete mixture consists of cement, fine and coarse aggregates. India possesses a . concluded that concrete with 10% replacement of granite chips possesses great strength and since granite . strength is quantified for varying percentage and grades of concrete by replacement of sand with quarry dust.

An Investigation into the Use of Manufactured Sand as a 100 . - MDPI

Jun 2, 2016 . Many studies have examined the influence of the partial replacement of fine aggregate in concrete using crusher dusts or small crushed sand samples on concrete properties [8,12,13]. However, little work has been performed on the complete replacement of natural fine aggregate in concrete with crusher.

Utilization of Construction Waste Tiles as a Replacement for Fine .

This study is an investigation into the utilization of waste tiles as partial replacement for fine and coarse aggregates in concrete. The control mix and other mixes containing cement, water, granite and partial replacement for sand with crushed tiles (in 5%, 10%, 15% and 20% proportions) were cast, cubed, cured and crushed.

A Study On The Strength Of Concrete Using Crushed Stone Dust as .

The equivalent mixes were obtained by replacing natural sand by stone dust partially and fully. The test results indicate the crushed stone dust waste can be used effectively to replace natural sand in concrete. In the experimental study of strength characteristics of concrete using crushed stone dust as fine aggregate it is.

granite fine sand replacement,mechanical properties of geopolymer concrete using granite slurry .

USING GRANITE SLURRY AS SAND REPLACEMENT . by replacing the fine aggregate using granite slurry at different levels (0%, 20%, 40% and 60%). . Sand. Natural river sand is used as fine aggregate. As per IS: 2386 (Part III)-1963 [8], the bulk specific gravity in oven dry condition and water absorption of the sand are.

paper presentation - SlideShare

Jan 10, 2016 . PARTIAL SAND REPLACEMENT IN CONCRETE WITH GLASS POWDER PRESENTED BY: CHITHIRA KRISHNAKUMAR S7 CIVIL ENGINEERING NiCE . Aggregates are classified as coarse (line or granite) and fine (sand) • Cement serves as a binder for the aggregate • Mix is hardened through a.

granite fine sand replacement,replacement of natural sand in concrete by waste products

Mar 25, 2013 . successful utilization of Crushed Granite Fine. (CGF) as fine aggregate would turn this waste material that causes an environmental load due to disposal problem into valuable resources, reduction in the strain on the supply of natural sand and economy in concrete production based on findings from the.

iron ore tailing as fine aggregate in mortar used - CiteSeerX

only river sand (RS) as fine aggregate served as the control mix, while sand was replaced in the other mixes by . of 80 kg of crushed waste glass was used as a partial replacement for sand at 10%, 15%, and 20% . Use of crushed granite fines or crushed rock fines as an alternative to sand in concrete production was.

An Experimental Investigation of Strength of “Granite Fines Concrete”

help to overcome the problem associated with its disposal including the environmental problems of the region. Accordingly this project work will examine M30 grades of concrete were cast by varying the percentage replacement of sand with granite fines. Granite fines. Granite Granites was used as fine aggregate in.

Experimental Study on Concrete Containing Granite Powder .

Here, cement is constantly replaced with waste granite powder by 10% and fine aggregate is partially replaced with waste foundry sand and copper slag in different percentages, viz., 0%, 10%, 20%, 30%, 40% and 50%.The aim of this study is to understand the effect of waste granite powder, waste foundry sand and copper.

Journal of Engineering Granite Fines as a Partial Replacement for .

Aug 8, 2012 . blocks, granites are sometimes used as a partial replacement of the sand content in the sand-cement matrix [Falade, 1993 1999] fine granites are readily available at line quarries in. Nigeria where line rocks are blasted to produce granite chippings. These chippings are now extensively used in.

influence of using granite waste on the mechanical . - ARPN Journals

mechanical properties of the control mix to the green concrete mixes containing 5% of fine granite waste as a partial replacement of cement, the splitting tensile strength was 20% higher, the flexural strength was 19% lower and the bond strength was slightly lower by 1%. Whereas, replacing sand in the concrete mixes by.

Comparative Analysis on Partial Replacement of Cement . - IJAERT

Comparative Analysis on Partial Replacement of Cement by Metakaolin and Fine Aggregate by Granite Powder. J. Thivya 1, M. Arivukkarasi2*. 1 Assistant Professor, Dept of Civil Engg, University college of Engineering, Dindigul, Tamilnadu. 2PG Scholar, Anna University Regional Campus, Madurai, Tamilnadu. Abstract.

Geo Polymer Concrete with the Replacement of Granite Aggregate .

granite fines content was the optimum value for improved structural performance. Kanmalai Williams C et al (2008) examined the performance of concrete made with the granite powder as fine aggregate. Sand was replaced with granite powder in steps of 0, 25, 50, 75 and and cement was replaced with 7.5%Silica.

Pre:groundnuts grinding machines prices in south africa
Next:used line crusher price in malaysia